Experimental studies of dynamic properties of corrosion-damaged compressed reinforced concrete elements
https://doi.org/10.33979/2073-7416-2022-100-2-55-64
Abstract
There are practically no results of experimental studies of elements made of compressed reinforced concrete damaged by corrosion in the scientific literature. As a result, it is almost impossible to reliably assess the state of deformation-deformation of these structures, especially under dynamic loads. For experimental studies, 37 samples of reinforced concrete were made-columns of square cross-section with dimensions of 100x100 mm, height of 700 mm. Local corrosion damages of concrete and reinforcement were created in reinforced concrete samples, while a concentrated (37%) hydrochloric acid (HCL) solution was used as an aggressor to accelerate the corrosion of elements. The article describes experimental studies on changing the dynamic properties of reinforced concrete elements that undergo corrosion during eccentrically compression. Based on strain gauge data, it was found that corrosion damage leads to a decrease in the height of the compressed concrete section by reducing the cross-section of the stretched reinforcing bars, as well as to the lack of joint work of reinforcing bars with concrete. According to strain measurement data, deformations of uncompressed and undamaged sections were obtained, which showed that the deformation diagrams fundamentally differ in their contour. The results obtained as a result of the study of the nature of deformation of reinforcement and concrete allowed us to assess the state of deformation stress of damaged and non- corroded structures according to the parameter Ne-1/r (curvature). The effect of corrosion damage on the nature of destruction of eccentrically compressed elements has been established.
About the Author
D. S. Popov
National Research Moscow State University of Civil Engineering
Russian Federation
Russian Federation
Popov Dmitry S. – candidate of technical sciences, senior lecturer of the department of Reinforced Concrete and Masonry Structures
Moscow
References
1. Tamrazyan A.G., Mineev M.S. On the appearance of cracks in a model of a thick-walled concrete cylinder during corrosion, taking into account the porous zone at the interface between reinforcement and concrete. Izvestiya vysshikh uchebnykh zavedeniy. Tekhnologiya tekstil'noy promyshlennosti. 2021. No. 3 (393). P. 159-165. DOI 10.47367/0021-3497_2021_3_159.
2. Tamrazyan A.G., Avetisyan L.A. Calculation of eccentrically compressed reinforced concrete elements for short-term dynamic load. Stroitel'stvo: nauka i obrazovaniye. 2013. No. 4. P. 2.
3. Pakhomova E.G., Kretova V.M., Gordeev A.V., Mayakov A.S. On the methodology for assessing the performance of reinforced concrete structures in case of violation of the adhesion of reinforcement with concrete in case of corrosion damage. Promyshlennoye i grazhdanskoye stroitel'stvo. 2011. No. 8. P. 28-29.
4. Tamrazyan A.G., Popov D.S., Ubysz A. To the dynamically loaded reinforced-concrete elements’ calculation in the absence of adhesion between concrete and reinforcement. IOP Conference Series: Materials Science and Engineering. 2020. Vol. 913. P. 022012. DOI: 10.1088/1757-899x/913/2/022012.
5. Stavskaya I.S., Markov S.V., Morozova O.V. Longitudinal cracks in the protective layer of concrete under conditions of corrosion damage. Building and reconstruction. 2012. No. 3 (41). P. 35-41.
6. Smolyago G.A. Modeling the magnitude of corrosion damage to reinforcement of reinforced concrete structures in a chloride aggressive environment. Izvestiya Yugo-Zapadnogo gosudarstvennogo universiteta. 2017. No. 1(70). P. 43-49. DOI 10.21869/2223-1560-2017-21-1-43-49.
7. Bondarenko V.M., Klyueva N.V., Kolchunov V.I., Androsova N.B. Some results of the analysis and generalization of scientific research on the theory of constructive safety and survivability // Building and Reconstruction. 2012. No. 4 (42). Рp. 3-16.
8. Falikman V.R. Stepanova V.F. A new methodological manual on the appointment of the service life of concrete and reinforced concrete structures, taking into account the impact of the operating environment on their life cycle. Vestnik NIC Stroitel'stvo. 2020. No. 4 (27). P. 126-134. DOI 10.37538/2224-9494-2020-4(27)-126-134.
9. Abosrra L, Ashour AF, Youseffi M. Corrosion of steel reinforcement in concrete of different compressive strengths. Construction and Building Materials. 2011;25(10):3915-3925.
10. Apostolopoulos Ch, Koulouris Konstantinos. Corrosion Effect on Bond Loss between Steel and Concrete. Structural Integrity and Failure. 2020. DOI: 10.5772/intechopen.94166
11. Lushnikova V.Yu., Tamrazyan A.G. The effect of reinforcement corrosion on the adhesion between reinforcement and concrete. Magazine of Civil Engineering. 2018. No. 4(80). Рp. 128–137.
12. Zandi K, Coronelli D. Anchorage capacity of corroded reinforcement: Eccentric pull-out tests on beam- end specimens. In: Report No. 2010-06, Department of Civil and Environmental Engineering. Goteborg, Sweden: Chalmers University of Technology.
13. Magda I. Mousa. Effect of bond loss of tension reinforcement on the flexural behavior of reinforced concrete beams. HBRC Journal, 2016, 12:3, 235-241, DOI: 10.1016/j.hbrcj.2015.01.003.
14. Raoul François, Wulong Zhangab, Ruiyan Wanga Yuxin Cai, Linwen Yuc. Corrosion behavior of stirrups in corroded concrete beams exposed to chloride environment under sustained loading. Construction and Building Materials. Volume 274, 8 March 2021, 121987. //doi.org/10.1016/j.conbuildmat.2020.121987
15. Almassri Belal, Barros Joaquim, Al-Mahmoud Firas, Francois Raoul. A FEM-based model to study the behavior of corroded RC beams shear repaired by NSM CFRP rods technique. Composite Structures. Volume 131. 2015. Pages 731-741. doi.org/10.1016/j.compstruct.2015.06.030.
16. Song L., Fan Z., Hou J. Experimental and Analytical Investigation of the Fatigue Flexural Behavior of Corroded Reinforced Concrete Beams. International Journal of Concrete Structures and Materials. 13(1):24 (2019). https://doi.org/10.1186/s40069-019-0340-5
17. Prokopovich A.A. Resistance to bending of reinforced concrete structures with different conditions of adhesion of longitudinal reinforcement to concrete. Samara, NVF "Sensors, Modules, Systems", 2000.
Review
For citations:
Popov D.S. Experimental studies of dynamic properties of corrosion-damaged compressed reinforced concrete elements. Building and Reconstruction. 2022;(2):55-64. (In Russ.) https://doi.org/10.33979/2073-7416-2022-100-2-55-64
Views:
219
Email this article 